Show Posts

This section allows you to view all posts made by this member. Note that you can only see posts made in areas you currently have access to.


Messages - piratemcgee

Pages: [1]
1
Montero Sport / Re: Interior Trim Clip Part #
« on: November 27, 2018, 09:23:01 AM »
Not sure (haven't counted) but I was able to track down MB814435 and MB317677. Looks like they are one in the same. I'll update once they come in.

2
Montero Sport / Interior Trim Clip Part #
« on: November 26, 2018, 03:54:29 PM »
Trying to replace some broken trim clips and can't seem to track down a part number. It's the clip used to hold the rear quarter panel interior trim on. They are white push clips with a square on one side. Does anyone know the part number (item 1 in diagram)?

3
Montero Sport / Re: Urgent: Stuck in 4 Hi, 3.5xs
« on: March 14, 2018, 06:25:31 PM »
Thanks Toasty.

4
Montero Sport / Re: Urgent: Stuck in 4 Hi, 3.5xs
« on: March 13, 2018, 10:04:29 PM »
What years of Montero have the white ball? 92-96?

5
Montero Sport / Re: Urgent: Stuck in 4 Hi, 3.5xs
« on: March 13, 2018, 08:20:08 PM »
Looks like it's the ball. I started taking the t-case shifter apart and as soon as I released tension on the 10mm surround nuts it popped back into 2wd. The shifter has always been pretty sloppy but since I had nothing to compare it to I figured it was normal these past 7 years.....

Am I better off getting a white ball shifter or just replacing the bushing MD701605?

6
Montero Sport / Urgent: Stuck in 4 Hi, 3.5xs
« on: March 13, 2018, 07:13:20 PM »
Hello all,

I have an urgent issue that suddenly arose this evening on my 2001 Montero Sport 3.5xs with the standard 2hi, 4hi, 4lo t-case. I bypassed the vacuum solenoid to engage the front diff years ago and installed manual hubs with a toggle switch to make the computer happy and locked the front diff engagement thing (I can't remember the name but it's a rod with a small gear on the end).

I replaced my rear brakes today (unrelated) and when on a short test drive where I attempted to engage the t-case on some dirt (to use 2-low). When I shifted (in N) to 4hi, it got stuck there and now won't go back into 2hi or 4low. It feels like the gears are bound up some how.

Ideas on troubleshooting or a fix?

This isn't my daily drive but I was planning on taking camping this weekend and could use quick help. I'm going to go consult the FSM in the mean time but am hoping some folks have an idea.

Thanks for the help.

7
Montero Sport / Re: Liftgate Window Dam Replacement
« on: July 28, 2017, 03:50:48 AM »
Turned out to be an only the lower dam that needed replaced which fid not require window removal but did require lots fo scrapping to get the old junk out.

8
Montero Sport / Re: Liftgate Window Dam Replacement
« on: July 13, 2017, 05:59:36 PM »
Thanks. It does look like it needs to come out but I appreciate a second opinion.

9
Montero Sport / Liftgate Window Dam Replacement
« on: July 13, 2017, 05:43:32 AM »
The window dam all the way around the rear glass on my 01 Sport is brittle, cracked and in disrepair. Can this be removed and replaced without removing the rear glass or does the glass have to come out?

10
Mitsubishi Related / Re: 1st Gen AVM Manual Hub install
« on: June 11, 2017, 11:22:03 AM »
Also works on some of the Sports! I'm running Aisins on mine.

11
Mitsubishi Related / Re: SR Air Locker into 3.5 Sport
« on: June 08, 2017, 10:14:37 AM »
I have a coils with 4.90s. I've also read that the Sport uses a different axle shaft.

12
Mitsubishi Related / SR Air Locker into 3.5 Sport
« on: June 07, 2017, 05:56:31 AM »
Has anyone successfully transplanted a SR air locker into a 4wd 2000+ 3.5 Sport (4.90s)? If so, what all is involved?

I found one case on the old Sport forum but the write up isn't very detailed and it involved a 2wd Sport.


Pages: [1]